SeaSafe Inboard / Stern Drive / Diesel Coverage Listing

SeaSafe Group

Inboard / Stern Drive / Diesel Coverage Listing

Inboard / Stern Drive / Diesel Coverage

ENGINE*

Internally lubricated parts contained within the cylinder block to include: Pistons, piston rings and pins, main bearings and rod bearings, crankshaft, connecting rods, camshaft, camshaft bearings, timing chain, gears and/or belt, valves, valve springs, valve guides and seats, valve push rods, lifters, oil pump. Rocker arm cover, harmonic balancer, oil pan, engine mounts. Distributor housing, shaft and bearings. Seals and gaskets of a covered component if defective. Engine head(s), engine block and/or cylinder barrels, intake manifolds only if damaged beyond repair as a result of a mechanical breakdown of one of the above covered components.

DIESEL ENGINES ONLY*

Cylinder head bolts, air intake housing, main bearing bolts, rod bolts, rocker arms, oil cooler housing, oil filter housing, flywheel housing, pump drive gears, front covers, idler gears, balancer cover housing.

TRANSMISSION

Internally lubricated parts contained within the transmission case. (Case if damaged beyond repair by a covered component). Transmission mounts and oil pan. Seals and gaskets of a covered component if defective.

V-DRIVE

Internally lubricated parts. (Case if damaged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

STERN DRIVE UPPER GEAR CASE

Internally lubricated parts. (Case if damaged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

STERN DRIVE LOWER UNIT

Internally lubricated parts. (Case if damaged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

IGNITION

Ignition module, ignition trigger coil, ignition high output coil, spark plug wires.

CLOSED COOLING SYSTEM

Engine water coolant circulating pump and heat exchangers. (For closed cooling system only).

ELECTRICAL

Altemator/stator, voltage regulator/rectifier, engine mounted terminal blocks, engine mounted wiring harness, electric choke element, starter motor, starter armature, starter field windings, starter magnets, brush holder and brushes, end caps and bushings, starter drive, starter solenoid.

CONTROLS

Shift and throttle control box parts to include: cams, eccentrics, shafts, pivots, bushings, housing, control arms/levers and knobs, shift control cable, throttle control cable, and ignition switch.

POWER STEERING

Steering control helm assembly, control rack and yoke assembly, power steering pump, power steering cylinder, steering wheel, steering wheel mounting hub. (Excludes cables). Seals and gaskets of a covered component if defective.

HYDRAULIC STEERING (MANUAL SYSTEMS)

Hydraulic steering head, hydraulic steering lines, hydraulic steering cylinder, hydraulic steering flow valves. (Excludes cables). Seals and gaskets of a covered component if defective.

POWER TRIM

Power trim and/or tilt motor, trim cylinders, cylinder rams, cylinder seals, cylinder mounts and pivots, trim motor actuator solenoids, trim wiring harness, trim master control switches, control valve, pump and reverse lock valve.

INTERMEDIATE HOUSING

Intermediate shaft bearings, U-joints, center yoke, drive yoke, gimbal bearings, steering yoke, engine coupler. Intermediate housing/gimbal housing if damaged beyond repair by a covered component. Seals and gaskets of a covered component if defective.

FUEL DELIVERY

(Including turbo chargers). Fuel injectors, fuel distributors, fuel injection pumps, ECU module, throttle position sensor, manifold absolute pressure sensor, manifold air temperature sender, idle speed control, mass air flow sensor, detonation/knock sensor, coolant sensor, ignition pick up sensor, fuel delivery pump, fuel pump diaphragm, flame arrestor. All internally lubricated parts located within the turbo charger, housing, wastegate actuator. Seals and gaskets of a covered component if defective.

*NOTE: Diesel Engine component coverage only applies if the covered items are listed as covered parts under the original manufacturer’s warranty terms and conditions.

Optional Accessory Programs

Accessory Programs are available as options on Your Service Contract provided that the option purchased is so noted on the Administrator copy of Your Service Contract application. Should the Stand-alone option box be checked on the Administrator copy of Your Service Contract application, coverage will be limited to components listed in the Optional Pak checked on Your application.

CRUISING PAK

Air Conditioner: Compressor, condenser, capacitor, water pump, relay, fans, heat exchanger, evaporator, control panel, thermostat.

Heating Unit: Heating elements, control panel, thermostat.

Interior Lighting: Light switches, lighting fixtures.

12-Volt/24-Volt Electrical: Battery charger/converter, .

Shore Power: Onboard receptacle, cap, shore power main switch, circuit panel, circuit breakers.

Inboard Drive Line: Shaft, stuffing box, shaft log, strut, rudder, rudder shaft, rudder log, steering arm, steering cylinder, hydraulic reservoir.

Appliances (Built-in): Refrigerator, range/cook top, oven, L.P. regulator, clothes washer, clothes dryer, microwave, ice-maker, disposal, central vacuum system (applies to built-in units only).

Water System: water pump, water heater, compressor, drain system, sump pump, fittings, faucets.

Head/Waste System: shower, toilet, sink(s), holding tanks, macerator, gate valves, connections, electric flush control, vacuum pump. Note: pipes and leaks from piping and vacuum accumulations are excluded.

Dual Station/Tower Control Set: Helm control, steering wheel, throttle/shift control box.

Horns: Air horns, air horn compressor, air solenoids, control panel, electric horn and control.

Electrical: Battery main switch, battery isolator, battery selector switch, battery box, fuse block/fuse holders, chart light, windshield wiper motor, transom light, bow light, docking lights, courtesy lights.

Anchor: Winch, electric windlass motor, bow pulpit guide, control panel.

Depth Finder: Depth sounder, transducer, mounting brackets and control cable. (Applies to one factory installed unit only).

Instrument Panel: (Factory installed only) Tachometer, speedometer, volt gauge, hour meter, oil pressure gauge, trim gauge, fuel gauge, temp gauge.

Stereo: CD Player, CD Changer, amplifier, cassette tape deck, AM/FM tuner. (Factory installed units only).

Compass: Compass head, mounting brackets (excludes digital model).

Remote Spotlight: Control panel, horizontal/vertical control motors, light housing.

Planing/Trim Tabs: Pump, trim cylinders, planing plates.

Hardware: Deck rails, grab rails, hand rails, bow eyes, rope cleats, anchor chocks, cockpit steps, top slides, door hinges and latches, deck plates, storage cover sockets and supports.

*Blockage: Blocking coverage per foot of hull length per covered mechanical breakdown, up to $50.00 on covered claims.

*Dockside Assistance: (26 foot vessels and over only). Dockside Assistance covers up to $50.00 of service call charges when in water repair is needed.

*Not included if Cruising Pak is purchased as a Stand Alone option.

RUNABOUT PAK

Digital Depth Finder: Depth finder, transducer, mounting brackets and control cable. (Applies to one factory installed unit).

Fish Finder: Fish finder, transducer, speed and temperature sensors, mounting brackets, control cable. (Applies to one factory installed unit).

Electrical: Interior courtesy lights, docking/bow lights, stem light, dual battery switch, cabin light fixtures, electric horn, windshield wiper motor.

Stereo: CD Player, amplifier, cassette tape deck, AM/FM tuner. (Factory installed units only).

Appliances (Built-in): Galley sink and faucet, ice box, stove top.

Water System/Washdown: water pumps, drain system, fittings, faucets.

Head/Waste System: shower, toilet, sink, holding tank, macerator, gate valves, connections,

Hardware: Stainless steel deck railings, grab rails, bow eyes, rope cleats.

Instrument Panel (Factory installed): Tachometer, speedometer, volt gauge, hour meter, oil pressure gauge, trim gauge, fuel gauge, temp gauge.

Trailer: Brakes, brake drums, master cylinder and hydraulic brake actuator. Frame rails, wheel bearings, spindles and springs, winch stand, welds, axle, backing plates, coupler, bunk and roller cradles. (Excludes damage due to overloading and bending or bearing failures due to water entry or debris).

SKI BOAT PAK

Digital Depth Finder: Depth finder, transducer, mounting brackets and control cable. (Applies to one factory installed unit).

Electrical: Interior courtesy lights, docking/bow lights, stem light, dual battery switch, cabin light fixtures, electric horn, windshield wiper motor.

Stereo: CD Player, amplifier, cassette tape deck, AM/FM tuner. (Factory installed units only).

Water/Ballast System/Washdown: water pumps, drain system, fittings, faucets.

Hardware: Stainless steel deck railings, grab rails, bow eyes, rope cleats.

Instrument Panel (Factory installed): Tachometer, speedometer, volt gauge, hour meter, oil pressure gauge, trim gauge, fuel gauge, temp gauge.

SAILBOAT CRUISING PAK

Air Conditioner: compressor, condensor, heat exchanger, evaporator, thermostat, capacitors, relays, fans. Failures due to corrosion and/or clogging of fittings, thru-hulls, hoses, cooling coils or tubes are excluded.

Heating: furnace, heating elements, control panel, thermostat, burner assembly, blower motor.

Water System: water pump, water heater, compressor, drain system, fittings and faucets.

Waste System: shower, toilet, sink(s), holding tanks, macerator, gate valves, connections and vacuum pump. Note: pipes and leaks from piping and vacuum accumulators are excluded.

Appliances: refrigerator, range/cook top, oven, clothes dryer, microwave, ice maker, trash compactor, central vacuum system (applies to built-in units only).

12 Volt Electrical: battery charger/converter, shore power, onboard receptacle, shore power main switch, circuit panel, circuit breakers.

Electrical: battery main switch, battery isolator, battery selector switch, battery box, fuse block, fuse holder, chart light, transom light, bow light, docking lights, voltmeter, electric horn, windshield wiper motor.

Instrument Panel: speedometer head, tachometer head, volt meter gauge, hour meter, oil pressure gauge, trim gauge, fuel gauge, temp gauge (applies to factory installed unit only).

Compass: compass head, mounting brackets (excludes digital models).

Bilge: pump, manual control panel, switches, wiring harness, venting system.

Remote Spotlight: control panel, horizontal/vertical control motors, light housing.

Horns: air horns, air horn compressor, air solenoids, control panel, electric horns.

Anchor: winch, electric winchless motor, bow pulpit guide, switches.

Speedometer/Tachometer: Speedometer head, tachometer head, speed log, speed sensor, mounting brackets, control cable.

Manual Steering: Tiller arm; drag link; stabilizer; rudder shaft tiller arm; u-joints; torque tube; gear box; steering control helm assembly; control rack and yoke assembly; steering wheel; steering wheel mounting hub (excludes cables).

Boat Hardware: Deck rails, grab rails, hand rails, bow eyes, line cleats, anchor chocks, cockpit steps, rod holders, top slides, door hinges and latches, deck plates, storage cover sockets and supports.

Blocking: In the event of a Failure of a covered component, Contract Holder will be reimbursed up to $50.00 per occurrence for blocking charges.

NAV PAK

Navigation System: Radar, GPS, GPS Map Receiver, LORAN, Plotter, Loran Antenna, Auto Pilot, VHF Radio.

GENERATOR PAK (Coverage is limited to the first 1500 hours of use for New Craft and 750 hours of use for Used Craft)

Engine: Internally lubricated parts contained within the cylinder block to include: Pistons, piston rings and pins, main bearings and rod bearings, crankshaft, connecting rods, camshaft, camshaft bearings, timing chain, gears and/or belt, valves, valve springs, valve guides and seats, valve push rods, lifters, oil pump. Rocker arm cover, harmonic balancer, oil pan, engine mounts. Distributor housing, shaft and bearings. Seals and gaskets of a covered component if defective. Engine head(s), engine block and/or cylinder barrels, intake manifolds only if damaged beyond repair as a result of a mechanical breakdown of one of the above covered components.

Electrical: Switch box/amplifier, alternator, voltage regulator/rectifier, ignition coil, starter motor, solenoid, engine mounted wiring harness.

Closed Cooling System: Engine water coolant circulating pump and heat exchangers. (For closed cooling system only).

Generator Electrical: Armature, fields, brushes, end frame and housing, generator mounted control panel, rectifier. (Does not include installation and/or removal of unit).

TRAILER PAK

Trailer: Brakes, brake drums, master cylinder and hydraulic brake actuator. Frame rails, wheel bearings, spindles and springs, winch stand, welds, axle, backing plates, coupler, roller cradles. (Excludes damage due to overloading and bending, and bearing failures due to water entry or debris).

REPOWER*

INBOARD, STERN DRIVE AND DIESEL COVERED COMPONENTS

Engine head(s), engine block and/or cylinder barrels, intake manifolds only if damaged beyond repair as a result of a mechanical breakdown of one of the above covered components.

Diesel Engine Only: Cylinder head bolts, air intake housing, main bearing bolts, rod bolts, rocker arms, oil cooler housing, oil filter housing, flywheel housing, pump drive gears, front covers, idler gears, balancing cover housing.

Electrical: Altemator/stator, voltage regulator/rectifier, ignition trigger coil, ignition high output coil, spark plug wires, engine mounted terminal blocks, engine mounted wiring harness, electric choke solenoid, starter motor, starter armature, starter field windings, starter magnets, brush holder and brushes, end caps and bushings, starter drive, starter solenoid.

Fuel Delivery: (Including turbo chargers). Fuel injectors, fuel distributors, fuel injection pumps, ECU module, throttle position sensor, manifold absolute pressure sensor, manifold air temperature sender, idle speed control, mass air flow sensor, detonation/knock sensor, coolant sensor, ignition pick up sensor, fuel delivery pump, fuel pump diaphragm, flame arrester. All internally lubricated parts located within the turbo charger housing, wastegate actuator. Seals and gaskets of a covered component if defective.

*NOTE: The Repower Program is for new replacement engines installed with the original V-drive, transmission or stern drive in your current boat.

Benefits

HOIST/HAUL-OUT: The Contract will pay up to $100.00 for the actual cost of Hoist/Haul-Out anytime a covered component fails requiring Hoist/Haul-out to facilitate diagnosis or repairs (except where prohibited by law). Any reimbursement shall be the actual Hoist/Haul-Out charges in excess of any applicable reimbursement from any other party, including but not limited to, a manufacturer, association or insurer.

TOWING: The Contract will pay up to $100.00 for towing anytime a covered component fails causing the Craft to be towed either in water or on land (except where prohibited by law). Any reimbursement shall be the actual Towing charges in excess of any applicable reimbursement from any other party, including but not limited to, a manufacturer, association or insurer. Towing must be performed by a valid marine towing company or authorized marine service facility.

PICK-UP/DELIVERY: The Contract will pay up to $100.00 for the actual cost of Pick-Up/Delivery for Craft up to 25 feet anytime a covered component fails requiring Pick-Up/Delivery to facilitate diagnosis or repairs (except where prohibited by law). Any reimbursement shall be the actual Pick-Up/Delivery charges in excess of any applicable reimbursement from any other party, including, but not limited to, a manufacturer, association or insurer.